The Cummins Diesel Engine M11 STC Celect Plus Industrial Operation and Maintenance manual has detailed illustrations as well as step by step instructions, and contains everything you need to repair,rebuild,refurbish or restore your Engine. All diagnostic and repair procedures are covered. You will find maintenance schedule and maintenace procedures to avoid future damage to your Cummins Diesel Engine M11 STC Celect Plus Industrial Operation and Maintenance.

This repair manual contains 856 PAGES high quality pages with all the details you need to get the job done in the fastest and cheapest way.

PLEASE NOTE:
You need to be connected to the internet to use this manual.

The index of our service manual contains:

Section i - Introduction
(99-204-001) To the Owner and Operator
(99-204-002-om-ind) About the Manual
(99-204-003-om-ind) How to Use the Manual
(99-204-004) Symbols
(99-204-005) Illustrations
(99-204-006-om-ind) General Safety Instructions
(99-204-007-om-ind) General Repair Instructions
(99-204-008) General Cleaning Instructions
(99-204-009) Acronyms and Abbreviations

Section E - Engine Identification
(36-100-001-om-ind) Engine Identification
(36-100-002-om-ind) Engine Diagrams

Section 1 - Operating Instructions
(99-101-999-om-ind) Operating Instructions - Overview
(101-101-014) Normal Starting Procedure
(101-101-004) Cold Weather Starting
(101-101-018) Starting Procedure After Extended Shutdown or Oil Change
(99-101-015-om-ind) Operating the Engine
(99-101-008-om-ind) Engine Operating Range
(99-101-009-om-ind) Engine Shutdown
(36-101-007-om-ind) Electronic Controlled Fuel System
(99-101-002) Electromagnetic Interference (EMI)

Section 2 - Maintenance Guidelines
(99-102-999) Maintenance Guidelines - Overview
(36-102-004) Tool Requirements
(36-102-002-om-ind) Maintenance Schedule
(99-102-001) Maintenance Record Form

Section 3 - Maintenance Procedures at Daily Interval
(99-103-999) Daily Maintenance Procedures - Overview
(99-006-043) Fuel-Water Separator
(99-007-043-om-ind) Lubricating Oil Level
(99-008-066) Coolant Level
(99-008-040) Fan, Cooling
(99-103-002) Drive Belts
(99-003-018) Crankcase Breather Tube
(99-012-021) Air Tanks and Reservoirs
(99-010-028) Charge Air Piping

Section 4 - Maintenance Procedures at 250 Hours or 6 Months
(99-999-999) Maintenance Procedures - Overview
(36-006-015-om-ind) Fuel Filter (Spin-on)
(36-007-002) Lubricating Oil and Filters
(36-007-013-om-ind) Lubricating Oil Filter (Spin-on)
(36-008-006-om-ind) Coolant Filter
(99-008-046) Supplemental Coolant Additive (SCA) and Antifreeze Concentration
(99-012-015) Air Compresser Discharge Lines
(36-019-043) Engine Wiring Harness

Section 5 - Maintenance Procedures at 1500 Hours
(99-999-999) Maintenance Procedures - Overview
(36-003-004-om) Overhead Set
(36-008-062-om) Water Pump
(36-008-049-om) Radiator Shutter Assembly
(36-010-033-om) Turbocharger
(101-016-010) Engine Mounts
(99-000-009) Engine Steam Cleaning
(99-010-059) Air Cleaner Restriction
(36-010-024-om-ind) Air Leaks, Air Intake and Exhaust Systems

Section 6 - Maintenance Procedures at 6000 Hours or 2 Years
(99-999-999) Maintenance Procedures - Overview
(36-008-018-om-ind) Cooling System

Section 7 - Maintenance Procedures at 6000 Hours
(99-999-999) Maintenance Procedures - Overview
(99-001-052) Vibration Damper, Viscous
(36-008-030-om) Fan Drive Idler Pulley Assembly
(36-010-033-om) Turbocharger
(36-008-036-om) Fan Hub, Belt Driven
(99-012-003) Air Compressor Carbon Buildup

Section A - Adjustment, Repair, and Replacement
(36-005-043) Fuel Shutoff Valve
(36-005-016-om-ind) Fuel Pump
(36-006-026-om-ind) Injector
(36-008-002-om-ind) Drive Belt, Cooling Fan
(36-013-005-om-ind) Drive Belt, Alternator
(36-013-021-om-ind) Belt Tensioner, Automatic (Alternator)
(36-008-062-om-ind) Water Pump
(36-008-013-om-ind) Coolant Thermostat
(36-008-030-om-ind) Fan Drive Idler Pulley Assembly
(36-008-036-om-ind) Fan Hub, Belt Driven
(36-010-033-om-ind) Turbocharger
(36-012-022) Air Starting Motor

Section D - System Diagrams
(00-200-999) System Diagrams
(36-200-001-om-ind) Flow Diagram, Fuel System
(36-200-002-om-ind) Flow Diagram, Lubricating Oil System
(36-200-003-om-ind) Flow Diagram, Cooling System
(36-200-004-om-ind) Flow Diagram, Air Intake System
(36-200-005-om-ind) Flow Diagram, Exhaust System
(36-200-006-om-ind) Flow Diagram, Compressed Air System

Section L - Service Literature
(36-205-001-om) Additional Service Literature
(99-205-002) Service Literature Ordering Location
(99-205-004) Customized Parts Catalog

Section S - Service Assistance
(99-202-002) Routine Service and Parts
(99-202-003) Emergency and Technical Service
(99-202-004) Problem Solving
(99-202-005) Division and Regional Offices
(99-202-006) Distributors and Branches
(99-202-007) Regional Offices - International
(99-202-008) Distributors - International

Section ES - Engine Storage
(99-000-005-om) Engine Storage - Long Term

Section TS - Troubleshooting Symptoms
(99-t00-001-om) Troublershooting Procedures and Techniques
(99-t00-002) Troubleshooting Symptom Charts
(3666117-t004-om) Air Compressor Air Pressure Rises Slowly
(3666117-t005-om) Air Compressor Cycles Frequently
(3666117-t006-om) Air Compressor Noise is Excessive
(3666117-t007-om) Air Compressor Pumping Excess Lubricating Oil into the Air System
(3666117-t008-om) Air Compressor Will Not Maintain Adequate Air Pressure (Not Pumping Continuously)
(3666117-t010-om) Air Compressor Will Not Stop Pumping
(3666117-t013-om) Alternator Not Charging or Insufficient Charging
(3666117-t020-om) Coolant Loss - External
(3666117-t022-om) Coolant Temperature Above Normal - Gradual Overheat
(3666117-t023-om) Coolant Temperature Above Normal- Sudden Overheat
(3666117-t024-om) Coolant Temperature is Below Normal
(3666117-t027-om) Crankcase Gases (Blowby) Excessive
(3666117-t033-om) Engine Acceleration or Response Poor
(3666117-t036-om) Engine Brake Does Not Operate
(3666117-t041-om) Engine Decelerates Slowly
(3666117-t043-om) Engine Difficult to Start or Will Not Start (Exhaust Smoke)
(3666117-t044-om) Engine Difficult to Start or Will Not Start (No Exhaust Smoke)
(3666117-t047-om) Engine Noise Excessive
(3666117-t048-om) Engine Noise Excessive - Combustion Knocks
(3666117-t057-om) Engine Power Output Low
(3666117-t061-om) Engine Runs Rough at Idle
(3666117-t062-om) Engine Runs Rough or Misfires
(3666117-t064-om) Engine Shuts Off Unexpectedly or Dies During Deceleration
(3666117-t066-om) Engine Speed Surges at Low or High Idle
(3666117-t067-om) Engine Speed Surges Under Load or in Operating Range
(3666117-t072-om) Engine Starts But Will Not Keep Running
(3666117-t075-om) Engine Vibration Excessive
(3666117-t077-om) Engine Will Not Crank or Cranks Slowly (Air Starter)
(3666117-t078-om) Engine Will Not Crank or Cranks Slowly (Electric Starter)
(3666117-t080-om) Engine Will Not Reach Rated Speed (RPM)
(3666117-t081-om) Engine Will Not Shut Off
(3666117-t087-om) Fuel Consumption Excessive
(3666117-t091-om) Fuel In Coolant
(3666117-t092-om) Fuel in Lubricating Oil
(3666117-t096-om) Intake Manifold Air Temperature Above Specification
(3666117-t097-om) Intake Manifold Pressure (Boost) is Below Normal
(3666117-t102-om) Lubricating Oil Consumption Excessive
(3666117-t103-om) Lubricating Oil Contaminated
(3666117-t104-om) Lubricating Oil Pressure High
(3666117-t105-om) Lubricating Oil Pressure Low
(3666117-t106-om) Lubricating Oil Sludge in the Crankcase Excessive
(3666117-t107-om) Lubricating Oil Temperature Above Specification
(3666117-t108-om) Lubricating or Transmission Oil in the Coolant
(3666117-t112-om) PTO or Cruise Control Does Not Operate
(3666117-t116-om) Smoke, Black - Excessive
(3666117-t118-om) Smoke, White - Excessive
(3666117-t122-om) Turbocharger Leaks Engine Oil or Fuel

Section V - Maintenance Specifications
(36-018-015-om-ind) General Engine
(36-018-016-om-ind) Fuel System
(36-018-017-om-ind) Lubricating Oil System
(36-018-018-om-ind) Cooling System
(36-018-019-om-ind) Air Intake System
(36-018-020-om-ind) Exhaust System
(36-018-021-om-ind) Electrical System
(36-018-022) Compressed Air System
(36-018-024) Cummins/Fleetguard® Filter Specifications
(101-018-002) Fuel Recommendations and Specifications
(101-018-003-om-ind) Lubricating Oil Recommendations and Specifications
(101-018-004-om-ind) Coolant Recommendations and Specifications
(99-018-005) Drive Belt Tension
(36-018-006) Engine Component Torque Values
(99-018-009) Capscrew Markings and Torque Values

Section W - Warranty

Cummins Diesel Engine M11 STC Celect Plus Industrial Operation and Maintenance Factory Service Repair Manual Product Info:

-to use this service manual you need only:
1.Adobe PDF Reader(recomanded) or any kind of pdf reader
2.WinRar(if the manual is archivated)

-All pages are printable with no restriction
-Delivery: Instant Download!!! No shiping cost!!! No waiting for your product!!!
-Checkout(payment procedures)-click on the download button or on the image of service manual and use paypal our credit card to make the payment after that you will recive the download link instantly.
-If you have any problem with our product or if you need more information dont hasitate to contact us at the email (digitalservicemanuals@yahoo.com)